Stairway Safety for Construction

Stairways, like ladders, are a source of accidents at construction sites. They are also a source for numerous OSHA citations. In September 2003, the following stairway violations were in the top 75 OSHA rules to receive citations:
- Stairways with four or more risers or rising more than 30", whichever is less, must have at least one handrail and one stairrail system along each unprotected side or edge.
- A stairway or ladder must be provided at all employee access points where there is a break in elevation of 19" or more, and no ramp, runway, sloped embankment, or personnel hoist is provided.
- Your employer must provide a training program, as necessary, for stairway use. The program must enable you to recognize hazards related to stairways, and must train you in the procedures to be followed to minimize these hazards.
- Unprotected sides and edges of stairway landings must be provided with guardrails.

OSHA has many rules that address design, stairrails, handrails, and maintenance. The following examples (of the many rules for stairways) point out some of these areas.

General
- Temporary stairways must have landings of not less than 30" in the direction of travel, and extend at least 22" wide at every 12' or less of vertical rise.
- Where doors or gates open directly on a stairway, a platform must be provided. The door swing must leave 20" of effective width.
- Proper housekeeping procedures eliminate stairway slip, trip, and fall hazards. Keep stairs free from debris and clutter.

Good lighting will help avoid stairway hazards. Like any other walking/working surface, it is difficult to avoid what you cannot see.

Stairrails and handrails
- Stairrails must not be less than 36 inches high from the tread to the top of the stairrail.
- Handrails must be between 30 and 37 inches high measured from the tread surface.
- Handrails must provide an adequate handhold to avoid falling. If the handrails are not permanent, there must be at least a three inch clearance between the handrail and wall.

Temporary stairs have their own issues
- Treads for temporary service must be made of wood or other solid material, and must be installed the full width and depth of the stair.

This information is provided by: Assurance Agency  http://www.assuranceagency.com